Study on Impact of Low Load to Frictional Coefficient of Silicon – Silicon Couple in MEMS Devices

Van Manh Phan1, Truong Sinh Nguyen2, Hong Phuc Pham2,
1 Military Technical Academy, 236 Hoang Quoc Viet, Bac Tu Liem, Hanoi, Vietnam
2 Hanoi University of Science and Technology, 1 Dai Co Viet, Hai Ba Trung, Hanoi, Vietnam

Main Article Content

Abstract

The paper proposes the experimental process to determine the impact of low load to frictional coefficient of silicon – silicon couple by pin on disk model. The first experiment was performed with range of contact load from 2 mN to 30 mN. The coefficient of friction (COF) of Si – Si couple varies from 0.15 to 0.16 and are considered to be constant and the COF of SiO2 – SiO2 couple changes from 0.35 to 0.24. When increasing the surface roughness, the COF of SiO2 – SiO2 couple changes from 0.15 to 0.30. Consequently, the impact of surface force on frictional properties of materials have to be involved during the prediction of potential behavior of materials. The impact of surface roughness and different frictional behaviors of silicon between low and normal load are also mentioned in the second experiment.

Article Details

References

[1]. A.D. Romig, M.T. Dugger, P.J. McWhorter, Materials issues in microelec-tromechanical devices: science, engineering, manufacturability and reliability. Acta Mater. 51, (2003) 5837–5866.
[2]. B. Bhushan and S. Sundararajan, Micro, nano scale Tribology of MEMS, Materials, Lubricants and Devices. Springer, (2011).
[3]. Yifeng Lu and Pengfei Gao, Friction Measurement and lubrication in Rotary Silicon MEMS Device. Chinese Academy of Sciences, 2011.
[4]. Bhushan, B., Handbook of Micro/Nanotribology. CRC Press LLC, 1999.
[5]. Mathew Mate, C., Tribology on the small scale - A bottom up approach to friction, lubrication and wear, New York, USA: Oxford University Press, 2008.
[6]. Kaneko, R., Microtribology today and tomorrow. Wear, 168, (1993) 1-5.
[7]. Bhushan, B. and A.V. Kulkarni, Effect of normal load on microscale friction measurements. Thin solid Films, 278 (1996) 49-56.
[8]. Rusu, F., et al., Analysis of the surface effects on adhesion in MEMS structures. Applied Surface Science 358, (2015) 634-640.
[9]. Guo, Z., et al., Research development of measuring methods on the tribology characters for movable MEMS devices: a review. Microsystem Technologies 15, no 3 (2008) 343-354.
[10]. Tribology, C.F., Hardware Installation & Applications manual: USA, 2009.
[11]. Sami Franssila, Introduction to Microfabrication-2nd Edition. John Wiley & Sons, 2004.
[12]. Hsu, T.R., Mems and Microsystems - Design, Manufacture, and Nanoscale Engineering, ed. 2: United State of America: 2008.
[13]. M. Binggeli and C. M. Mate, Influence of water vapor on nanotribology studied by friction force microscopy. Journal of Vacuum Science & Technology B 13, 1312 (1995).
[14]. M. Scherge, X. Li và J.A. Schaefer, The effect of water on friction of MEMS. Tribology Letters. 6, (1999) 215-220.